HELP!!!!Дoug you call always call your local cat forklift dealer and they can point you in a good direction as if it is a common issue with that model or if they have seen it before. Posted 10:09 (#548105 - in reply to #547718) Subject: Re: Forklift Has NO Power. Look for a wire near the starter relay or battery that has gone limp. Posted 09:47 (#548087 - in reply to #548071) Subject: Re: Forklift Has NO Power. Some electrical systems have a fusable link in the wiring harness. Posted 09:33 (#548071 - in reply to #547718) Subject: Re: Forklift Has NO Power. Ifthey go bad it will kill everything whether in park or not. Some forklifts have a relay that requires being in nuetral or park to start. Posted 08:40 (#548040 - in reply to #547887) Subject: Re: Forklift Has NO Power. You might check the ignition switch as it could have burned in the process without the engine starting. I had this same problem with a truck and it turned out to be a 70 amp breaker that had burned out. There may be a circuit breaker (a big one ) somewhere that opened or burned out. Posted 23:02 (#547887 - in reply to #547718) Subject: Re: Forklift Has NO Power. You will just have to start checking with a 12 v probe light or Volt meter till you find where the power quits. You might have messed up a solenoid are burnt the connections on it before you could get the battery disconected. Check to make sure you are getting current through the battery cables and that you have a good ground. Check it with a load meter if you can or swap another battery in its place. Posted 21:37 (#547808 - in reply to #547718) Subject: Re: Forklift Has NO Power. The dash lights and headlights don't work either. I have absolutly no power when I turn the key on. Put the charger on it and it checked out good. Posted 21:32 (#547801 - in reply to #547718) Subject: RE: Forklift Has NO Power. Maybe when starter stuck, connections got burnt or solenoid itself is the issue. HELP!!!!Д¬heck the connections at the starter, in some instances all power comes from the solenoid to the rest of the vehicle. Posted 20:45 (#547756 - in reply to #547718) Subject: Re: Forklift Has NO Power. Posted 20:29 (#547743 - in reply to #547718) Subject: Re: Forklift Has NO Power. Please, any help would be greatly appreciated. I checked the fuse panel but could not find anything there either although it was dark and I did it with a flashlight. I cleaned the connections and still nothing. After reconnecting the battery I now have no lights or power at all. I quickly pulled the battery terminal and shut it down. Well anyway I decided to change plugs today and then went to start it and the starter stuck. It has been very hard to start but once it starts it runs like a champ. I beleive it has a 4 cylinder mitsubishi and runs on LP. HELP!!!!Д«ought a 2000 model cat GP25K a week ago. Posted 20:05 (#547718) Subject: Forklift Has NO Power. HELP!!!! Jump to page : 1 Now viewing page 1 ( logon | register )ДЇorklift Has NO Power.

Champ forklift dealer